Friends, today we present to you the Skoda Octavia A5 1.8tsi with a manual transmission and K04 turbo.
A year ago, the car was tuned to K04 with the Etuners program with limitations for stock clutch. The estimated power was around 315-320hp and 380Nm. The car covered 100-200km/h in 13 seconds according to data from RaceLogic, with the proprietary NoLiftShift option, this option allows not to lose turbo pressure when shifting gears.
A year later, the car acquired a complete set of hardware:
Apr Carbonio
Full Exhaust 76mm
APR IC
Custom boost pipes
2.0tsi injectors
Upgraded clutch
Additionally, AEM Water-Methanol system was installed.
The system had to be connected by myself right on the stand, as one of the installers did not connect the wiring, it was simply twisted with tape.


Customer's technical task:
Tune the car for 98 gasoline + water-methanol injection with the ability to drive without restrictions with the water-methanol injection system turned off.
Absence of explosive torque and, if possible, push the maximum acceleration to high revs.
Final result:

The maximum boost was 1.4bar, the car accelerates without wheel spin from second gear, the speed gain is aggressive with torque growth up to the cutoff. The engine is not loaded with torque, as the customer wanted.
The software includes Etuners traction control (details in the link below):
Review of the Etuners K04 2.0TSI firmware and measurement on the stand — 411 hp / 600 Nm
For the manual transmission, NoLiftShift can be optionally activated, a function that allows not to lose boost during shifts, while not creating shock loads on the transmission. And if desired, you can arrange a colorful show with fire from the exhaust system. =)
Just watch this short video:
This configuration can be used with the water-methanol injection completely turned off without any restrictions. No switches or reprogramming are required!
In conclusion, the acceleration result using RaceLogic:

And several runs sent by our client:
Run without methanol, time 100-200km/h about 10.0-10.2 seconds
Run with methanol, time 100-200km/h about 9.1-9.2 seconds
Sincerely
Etuners Russia
www.etuners.gr/
etuners.ru/
vk.com/etunersrussia
www.facebook.com/etunersmoscow
www.instagram.com/etuners_moscow/